500kW Containerized
Diesel Generator Set
Model
Emissions
Standby Rating
Prime Rating
60 Hertz
EGC-500C
EPA Certified
500kW (625kVA)
450kW (562.5kVA)
(Shown with optional ISO trailer chassis)
Standard Features
Cummins Heavy Duty Diesel Engine
Full Load Acceptance
„
„
„
„
4-cycle design, turbocharged, aftercooled, direct injection
Polymide blade cooling fan
„
Accepts 100% of standby nameplate rating in one step, in compliance
with NFPA, para 5-13.2.6
Engine coolant heater
Generator Control Panel
Meets EPATier 2 emissions standards
„
„
„
„
„
„
Basler vibration-isolated controller
Manual or remote engine start/stop
RS485/Modbus communication support
Safety shutdowns
Fuel System
„
„
„
„
„
„
800 gallon, single wall fuel tank
Fuel priming system
Externally mounted emergency stop switch
Fuel/water separators and drip pan
Electric fuel run pump
Generator mainline circuit breaker, 100% rated, electronically
operated, UL listed
External fuel fill
30 micron Racor® fuel filter system
Specially Designed Container
„
20 ft.ISO container, sound-attenuated, foam-lined for extremely quiet
operation
Alternator
„
„
Brushless, 4-pole, synchronous, WYE connection
„
„
„
Solidly mounted battery rack and cooling system
Intregral vibration isolators
Class H insulation system conforms to NEMA MG1-22, BS5000,
CSA-C22-2, IEC-34-1 standards for temperature rise
Exterior polyurethane coating system provides long life in extreme
operating conditions
„
„
Drip-proof, self-venting, amortisseur windings
Epoxy impregnated windings with tropical insulation for increased
environmental protection and long life
„
„
„
Interior DC lights and timer switch
Crankcase filtration system
Electronic Voltage Regulator
Critical grade silencer with heat blankets
„
„
Electronic automatic voltage regulator provides precise regulation
Warranty
Engine-generator sets are covered by an express written, one-year
limited warranty
Separate three-phase excitation for fast recovery from block loads
and motor starting
„
EGC500C Rev 0
500kW Containerized
Diesel Generator Set
Cooling System
Exhaust Manifold Type
Radiator Design
Dry
Standard horizontal discharge
Coolant Capacity - Engine
Water Pump Design/Type
Coolant Flow
6.3 gal. (24 L)
Belt Driven, Centrifugal
87 gal/min (329 L/min)
7830 BTU/min (138 kW)
10 psi (70 kPa)
Heat Rejection to Coolant
Minimum Pressure Cap
Thermostat Range
180-200 °F (82-93 °C)
Fuel System
DGC-2020 Digital Genset Controller
Digital Controller Features
Recommended Fuel
Fuel Pump Maximum Lift
Filter Micron Size - 98% Efficiency
Total Fuel Flow
ASTM-D975-No.1 or No. 2-D
6.0 ft. (1.8 m)
2
■
■
■
■
■
■
■
■
■
■
■
Local and Remote Generator Control
Automatic and manual starting and stopping
Engine and Generator Protection
Programmable Analog Engine Senders
ECU Communications via SAE J1939
16 Programmable Contact Inputs
Programmable Logic
112 gal./hr. (424 L/Hr.)
800 gal (3028 L)
Fuel Tank Capacity
Fuel Consumption - gal/hr (L/hr)
Diesel Fuel @ % of Load
Standby
11.6 (43.9)
18.8 (71.1)
25.7 (97.2)
34.4 (130.2)
Prime
25%
50%
9.9 (37.4)
17.2 (65.3)
23.9 (90.5)
31.1 (117.8)
75%
100%
Automatic Transfer Switch Control (Mains Failure)
Integrated RS485
Auto Synchronizing
Lubrication System
Type
Event recording
Full Pressure System
Spin-on, Full Flow
22 gal. (83.0 L)
Monitoring
Oil Filters
■
■
■
■
■
■
■
■
■
■
■
■
■
■
■
Engine RPM
Oil Pan Capacity
Engine run time
Oil Capacity with Filters
Oil Pressure at Rated Speed (minimum)
24 gal. (91.0 L)
Generator voltage
20 psi (138 kPa)
Generator current
Generator frequency
Oil pressure
Battery voltage
Exhaust System
Fuel level measurements
Running Hour Meter
o
o
Exhaust Temperature at Rated kW
Exhaust Flow at Rated kW
Silencer Type
875 F (468 C)
3200 cfm (90.6 m3/min)
Critical
Coolant temperature
Maximum Allowable Backpressure (standby)
Exhaust Outlet Size at hook-up
40.2 in/wc (10 kPa)
5.0 in. (127 mm)
Generator under/over voltage alarm/shutdown
Generator under/over frequency alarm/shutdown
Over Current alarm/shutdown
Warm up and cooling functions
Maintenance timer
EGC500C Rev 0
500kW Containerized
Diesel Generator Set
Optional Features and Accessories
Generator Set
Container
„
„
„
„
Genset-to-Genset Paralleling Control System
„
„
„
„
ISO Trailer Chassis (20 ft.)
Double-wall Fuel Tank (900-gallon capacity)
Fluid Containment
Base Load-to-Utility Paralleling Control System
Custom Outlet Panels
Manual Fuel Valves (For Internal or External Fuel
Supply)
Rotary Voltage Selector Switch
(High Wye/Low Wye Voltages)
„
Fueling Platform (Aluminum Step Construction
with Hand Rail)
„
„
„
„
„
Auxiliary Oil Reservoir with Level Control (10-gallon)
Centrifugal Oil Filter System
„
„
„
„
Personnel Ladder (Aluminum Construction)
Interior Lights (AC Work lights)
Oil Pan Heater with Thermostat
Alternator Strip Heater
Custom Paint Colors (Artic White is Standard)
Utility Grade Protective Relay
AC Battery Charger with Shore Power Receptacle
SPECIAL OPTIONS AVAILABLE UPON REQUEST
20 ft. Container
Weight and Dimensions
A
B
C
D
E
96 in.
(2,438 mm) (6,045 mm) (3,810 mm) (4,495 mm) (1,117 mm)
238 in.
150 in.
177 in.
44 in
Weight (Wet)*
20,440 lbs (9,271 kg)
26,920 lbs (12,211 kg)
Weight (Wet with trailer)*
* Weight is approximate. Wet weight does not include fuel.
Backfeed to a utility system can cause electrocution and/or property
damage. Do not connect to any building’s electrical system except
through an approved device. Specifications are subject to change
without notice.
Your MQ Power dealer is:
MQ POWER
POST OFFICE BOX 6254
CARSON, CA 90749
310-537-3700
•
800-421-1244
FAX: 310-632-2656
E-MAIL: [email protected]
© COPYRIGHT 2007, MQ POWER
Rev 0 (12-07) EGC500C
|